Exhaust Gaskets

Anything you like about motorbikes
Post Reply
User avatar
Ditchfinder
Posts: 1491
Joined: Thu Dec 24, 2020 8:55 am
Has thanked: 862 times
Been thanked: 1071 times

Exhaust Gaskets

Post by Ditchfinder »

I've always been aware of needing the copper gasket at the manifold / head junction but up until now didn;t realise you needed gaskets at the junctions between headers/link-pipes and link-pipes/silencers.

How much damage have I likely done riding without them ?

When I replaced the silencers on the Triumph there weren't any gaskets present so didn't think anything of it but looking back I was conscious of a leak near the silencer/link pipe which I used exhaust putty on to solve.

Is it best to use gaskets or is there a kind of universal solution like tape/paste that works OK?
'94 Sprint 900 and the scabbiest Himalayan in the country
User avatar
Rockburner
Posts: 6043
Joined: Sun Mar 15, 2020 11:06 am
Location: Hiding in your blind spot
Has thanked: 10971 times
Been thanked: 4004 times

Re: Exhaust Gaskets

Post by Rockburner »

Not all bikes have them. Depends on the way the manufacturer has set things up. I'm guessing they may be more prevalent on more modern bikes where the manufacturers are chasing lower emissions.
non quod, sed quomodo
User avatar
Ditchfinder
Posts: 1491
Joined: Thu Dec 24, 2020 8:55 am
Has thanked: 862 times
Been thanked: 1071 times

Re: Exhaust Gaskets

Post by Ditchfinder »

I'm thinking a smear of RTV sealant might do the job just as well too :idea:
'94 Sprint 900 and the scabbiest Himalayan in the country
User avatar
MrLongbeard
Posts: 6360
Joined: Sun Mar 15, 2020 2:06 pm
Has thanked: 780 times
Been thanked: 3224 times

Re: Exhaust Gaskets

Post by MrLongbeard »

If it didn't have any to begin with, and it you've got 'em good n tight with no leaks I'd not worry.
The Harley doesn't use gaskets at the silencers junction, but I used a very thin smear of assembly paste when swapping them out, more out of habit than need though.
Le_Fromage_Grande
Posts: 12162
Joined: Mon Mar 16, 2020 6:40 pm
Location: On the road to nowhere
Has thanked: 602 times
Been thanked: 4529 times

Re: Exhaust Gaskets

Post by Le_Fromage_Grande »

Ditchfinder wrote: Wed Aug 06, 2025 11:24 am I'm thinking a smear of RTV sealant might do the job just as well too :idea:
Use exhaust assembly paste, rtv will melt or catch fire
User avatar
Rockburner
Posts: 6043
Joined: Sun Mar 15, 2020 11:06 am
Location: Hiding in your blind spot
Has thanked: 10971 times
Been thanked: 4004 times

Re: Exhaust Gaskets

Post by Rockburner »

Le_Fromage_Grande wrote: Wed Aug 06, 2025 2:32 pm
Ditchfinder wrote: Wed Aug 06, 2025 11:24 am I'm thinking a smear of RTV sealant might do the job just as well too :idea:
Use exhaust assembly paste, rtv will melt or catch fire
I tend to use Dow Corning silicon seal, just the regular bathroom stuff. Works fine. I think you can get a high-temp version, but the regular stuff works.
non quod, sed quomodo
User avatar
ZRX61
Posts: 9063
Joined: Tue Mar 17, 2020 4:05 pm
Location: Solar Blight Valley
Has thanked: 2296 times
Been thanked: 2684 times

Re: Exhaust Gaskets

Post by ZRX61 »

No gaskets on the ZRX11 Muzzy Megaphone... the pipes slide together in an "almost interference" fit... If there was a leak I doubt anyone would be able to hear it anyway.
roadster
Posts: 263
Joined: Sun Mar 05, 2023 9:05 am
Has thanked: 29 times
Been thanked: 214 times

Re: Exhaust Gaskets

Post by roadster »

I'm a firm believer in generous application of copperslip or other copper based grease for the joint surfaces and for the clamp inner surface and threads too. Assembly is much easier and clamps pull up tighter with lubrication. Then as the grease heats up a firm copper residue seals the joint. Its easier to take apart even after a long period. It can be messy but if excess is cleaned off after one heat cycle it doesn't stain the chrome. Exhaust sealers that set hard usually go brittle and crumble away in time because some movement and vibration is always present.
Post Reply